Yamaha nouvo lc 135 service manual. Extra Speed Yamaha Nouvo Z Service Manual Download

Yamaha nouvo lc 135 service manual Rating: 9,3/10 1762 reviews

Moto TH

yamaha nouvo lc 135 service manual

Drain: 9fuel from float chamber 1 8. Therefore, anyone who uses this book to perform maintenance and repairs on Yamaha vehicles should have a basic understanding of mechanics and the techniques to repair these types of vehicles. Install: 9brake torque rod to brake shoe plate 19 Nm 1. This will speed up assembly and allow for the correct installation of all parts. Normal color is medium-to-light tan.

Next

Moto TH

yamaha nouvo lc 135 service manual

Charging coil resistance 9Connect the engine tachometer to the spark plug lead. Thoroughly clean all the gasket surfaces and crankcase mating surfaces. Calculate the piston-to-cylinder clearance with the following formula. Install: 9starter clutch 1 14 Nm 1. Spin the rear wheel several times and find the tightest position of the drive chain. Wireharness and cable guide clearance is wit in 16 mm, when straight the steering condition.

Next

Yamaha Nouvo review

yamaha nouvo lc 135 service manual

Hold the main body 1 of the rear brake light switch so that it does not rotate and turn the adjusting nut 2 in direction a or b until the rear brake light comes on at the proper time. When disassembling, always keep mated parts together. ˚ Pass through the drain hose into the hole of the protector. ¬ Pass through the high tension cord, fan motor lead and thermo sensor lead into the cut part on the plate. Open the seat and battery cover. Remove the bearing race from the lower bracket with a floor chisel 2 and hammer. Install: 9headlight bulb Secure the new headlight bulb with the headlight bulb holder.

Next

Extra Speed Yamaha Nouvo Z Service Manual Download

yamaha nouvo lc 135 service manual

Install: 9water pump housing cover 2 10 Nm 1. Disconnect: 9meter assembly couplers 1 9right handlebar switch coupler 2 9left handlebar switch coupler 3 9front brake light switch connectors 4 2 4 1 3 4. Use only the proper tools and cleaning equipment. Special tools, part numbers or both may differ depending on the country. If the thermo sensor is dropped, replace it. After installing the valve guide, bore the valve guide with the valve guide reamer 3 to obtain the proper valve-stem-to-valveguide clearance.

Next

Yamaha Nouvo

yamaha nouvo lc 135 service manual

Horn switch 9Check the horn switch for continuity. Disconnect: 9spark plug cap 3. Battery 9The radiator fan motor fails to turn. Turn signal indicator light bulb and socket 9Check the turn signal light bulb and socket for continuity. Compression pressure at sea level Minimum 2 490 kPa 4.


Next

Moto TH

yamaha nouvo lc 135 service manual

Hold the lower ring nut with a ring nut wrench 4 and tighten the upper ring nut 2 with a steering nut wrench. Tighten: 9cylinder head bolts 1 3 22 Nm 2. In recent years, the Nouvo has rapidly gained popularity as a platform for modification and customization e. Remove: 9speedometer cable 1 9axle nut 2 9washer 3 3 2 1 3. Pull back the adjusting nut cover. Replace: 9blown fuse w Never use a fuse with an amperage rating other than that specified. Install: 9copper washer 9coolant drain bolt 7 Nm 0.

Next

Yamaha Nouvo review

yamaha nouvo lc 135 service manual

Front : telescopic fork Rear: Swingarm brake System. Install: 9O-rings 9water pump housing 1 1 10 Nm 1. Front wheel radial runout limit 1. After adjusting the throttle position sensor angle, tighten the throttle position sensor screws. Repair and maintenance work attempted by anyone without this knowledge is likely to render the vehicle unsafe and unfit for use. Be careful not to get injured when the piston are expelled from the brake caliper.

Next

Yamaha Nouvo review

yamaha nouvo lc 135 service manual

Maximum cylinder head warpage 0. Connect: 9headlight connectors 1 2. Wireharness 9Check the wireharness for continuity. Place the vehicle on a suitable stand so that the front wheel is elevated. Install: 9thermostat 1 9thermostat cover 2 9bracket 10 Nm 1. A: Width across flats B: Thread diameter Ex.

Next

Yamaha Nouvo

yamaha nouvo lc 135 service manual

If the battery breather hose is positioned so as to allow electrolyte or hydrogen gas from the battery to contact the frame, the vehicle and its finish may be damaged. The radiator fan motor is faulty and must be replaced. Wiring 9Check the entire ignition system wiring. Tighten the bleed screw to specification. Remove: 9dust seal 1 9oil seal clip 2 with a flat-head screwdriver cC Do not scratch the inner tube.

Next

Yamaha Nouvo review

yamaha nouvo lc 135 service manual

If the continuity reading is incorrect, check the wiring connections and if necessary, replace the switch. Meter light bulb and socket 1. Radiator cap opening pressure 93. Work slowly and carefully and make sure the crankcase halves separate evenly. Tap only on reinforced portions of the crankcase, not on the crankcase mating surfaces. Wire harness The coolant temperature warning indicator light starts to display the self-diagnosis sequence. Fuel sender 9Remove the fuel sender from the fuel tank.

Next